Yamaha 75-115 HP Inline 4 200-250 HP 3.3L V6 Outboard (00-13) Shop Manual

CHAPTER ONE / GENERAL INFORMATION
Manual organization / Warnings, cautions and notes / Safety / Service hints / Outboard engine identification / Engine operation / Fasteners / Lubricants / RTV gasket sealant / Anaerobic sealant / Threadlocking compound / Galvanic corrosion / Propellers / Basic hand tools / Special tools / Precision measuring tools / electrical system fundamentals / Basic mechanical skills / Specifications

CHAPTER TWO / TROUBLESHOOTING
Electrical component replacement / Preliminary inspection / Starting difficulty / Electric starting system troubleshooting / Fuel system troubleshooting / Ignition system troubleshooting / Warning system troubleshooting / Charging system troubleshooting / Power head / Cooling system troubleshooting / Gearcase troubleshooting / Trim/tilt system troubleshooting / Electronic fuel injection system / Specifications

CHAPTER THREE / LUBRICATION, MAINTENANCE AND TUNE-UP
Before each use / After each use / Routine maintenance / Tune-up / Storage preparation and re-commissioning / Submersion / Corrosion prevention / Specifications

CHAPTER FOUR / TIMING, SYNCHRONIZATION AND ADJUSTMENT
Pilot screw adjustment (75-100 hp models) / Linkage, throttle position sensor, synchronization and idle speed adjustments / Ignition timing check / Throttle cable adjustment / Shift cable adjustment / Valve adjustment / Trim tab adjustment / Trim position sender adjustment / Specifications

CHAPTER FIVE / FUEL SYSTEM
Fuel system service / Fuel tanks / Fuel hoses / Fuel filter / Primer bulb replacement / Mechanical fuel pump / Silencer cover removal and installation / Intake manifold removal and installation / Dashpot replacement / Electrothermal valve replacement / Carburetor / Throttle body removal and installation / Vapor separator tank / Low-pressure electric fuel pump replacement / Fuel pump relay replacement / Fuel pump driver replacement / Fuel cooler replacement / Fuel pressure regulator replacement / Fuel rail and injectors / Idle air control motor replacement / Air temperature sensor replacement / Air pressure sensor replacement / Throttle position sensor replacement / Specifications

CHAPTER SIX / ELECTRICAL AND IGNITION SYSTEMS
Electrical component replacement / Battery / Charging system / Starting system / Ignition system / Specifications

CHAPTER SEVEN / POWER HEAD
Flywheel/cover removal and installation / Timing belt and tensioner removal/installation / Valve cover removal and installation / Camshaft, timing chain and camshaft pulley removal and installation / Cylinder head removal and installation / Water pressure relief valve removal and installation / Thermostat removal and installation / Exhaust/water jacket cover removal and installation / Cylinder head disassembly/inspection/assembly / Power head removal and installation / Oil pump / Oil pump inspection / Crankshaft pulley removal and installation / Power head external component removal and installation / Cylinder block disassembly and assembly / Cylinder block component inspection and measurement / Bearing selection / Engine break-in procedures / Specifications

CHAPTER EIGHT / GEARCASE
Gearcase operation / Gearcase service precautions / Propeller removal and installation / Gearcase removal and installation / Water pump disassembly/assembly / Gearcase disassembly and assembly / Gearcase component inspection / Gearcase shimming / Gearcase pressure test / Specifications

CHAPTER NINE / POWER TRIM AND TILT
Trim/tilt relay replacement / Trim position sender replacement / Trim switch replacement / Manual relief valve replacement / Power trim and tilt system removal and installation / Electric trim/tilt motor removal/installation / Electric trim and tilt motor disassembly, component inspection, testing and assembly / Fluid filling / Specifications

CHAPTER TEN / MIDSECTION
Lower motor mount replacement / Tilt tube replacement / Clamp bracket replacement / Tilt lock lever replacement / Oil pump replacement / Upper motor mount replacement / Swivel tube replacement / Swivel housing replacement / Power head adapter replacement / Exhaust silencer replacement / Exhaust tube replacement / Oil pressure relief valve / Oil pan and oil pickup tube replacement / Drive shaft housing replacement / Specifications

CHAPTER ELEVEN / REMOTE CONTROL
Remote control operation / Cable removal and installation / Remote control disassembly and assembly / Specifications

INDEX

COLOR WIRING DIAGRAMS

Models covered:
2000 2001 2002 2003 2004 2005 2006 2007 2008 2009 2010 2011 2012 2013 Yamaha 75 HP
2000 2001 2002 2003 2004 2005 2006 2007 2008 2009 2010 2011 2012 2013 Yamaha 80 HP
2000 2001 2002 2003 2004 2005 2006 2007 2008 2009 2010 2011 2012 2013 Yamaha 100 HP
2000 2001 2002 2003 2004 2005 2006 2007 2008 2009 2010 2011 2012 2013 Yamaha 115 HP
2000 2001 2002 2003 2004 2005 2006 2007 2008 2009 2010 2011 2012 2013 Yamaha 200 HP
2000 2001 2002 2003 2004 2005 2006 2007 2008 2009 2010 2011 2012 2013 Yamaha 225 HP
2000 2001 2002 2003 2004 2005 2006 2007 2008 2009 2010 2011 2012 2013 Yamaha 250 HP



Clymer Manuals Yamaha 75 HP Manual
Clymer Manuals Yamaha 80 HP Manual
Clymer Manuals Yamaha 90 HP Manual
Clymer Manuals Yamaha 100 HP Manual
Clymer Manuals Yamaha 115 HP Manual
Clymer Manuals Yamaha 200 HP Manual
Clymer Manuals Yamaha 225 HP Manual
Clymer Manuals Yamaha 250 HP Manual
Clymer Manuals Yamaha 75 HP Online Manual
Clymer Manuals Yamaha 80 HP Online Manual
Clymer Manuals Yamaha 90 HP Online Manual
Clymer Manuals Yamaha 100 HP Online Manual
Clymer Manuals Yamaha 115 HP Online Manual
Clymer Manuals Yamaha 200 HP Online Manual
Clymer Manuals Yamaha 225 HP Online Manual
Clymer Manuals Yamaha 250 HP Online Manual



Yamaha 75 HP (2000-2013)
Yamaha 80 HP (2000-2013)
Yamaha 90 HP (2000-2013)
Yamaha 100 HP (2000-2013)
Yamaha 115 HP (2000-2013)
Yamaha 200 HP (2000-2013)
Yamaha 225 HP (2000-2013
Yamaha 250 HP (2000-2013)